Post by Bob on Sept 5, 2020 23:29:27 GMT
Rechargeable Lithium Ion batteries are potentially hazardous when used incorrectly. Batteries can present a serious FIRE HAZARD if damaged, as well as improperly used, stored or charged.
Every 18650, 20700, 21700 etc battery in the market today, is a Lithium-Ion battery cell. Here are some important safety tips for rechargeable batteries:
Battery Damage: Never use a damaged battery, such as a dented battery or a battery that has its wrapping damaged. The plastic wrap on the battery and the white insulator on the positive side protects the battery from venting.
Charging: It is highly recommended to not use the micro USB charging port to recharge your device, especially if it is a device that uses 2 or more batteries. A micro USB cable and a wall-charging block are not designed to handle the proper voltage & current. The micro-USB port is mostly designed for firmware updates.
Charger Type: It is preferable to use an external Lithium Ion battery charger. These specific chargers provide a microchip that charges your batteries at the proper voltage, voltage control & overcharge protection.
Discharge: Never fully discharge a battery, but if you do so, you MUST recharge the battery within 24 hours in a proper external battery charger.
Voltage Drop-Off: Fully discharging a battery leads into the topic of battery voltage drop-off, which occurs when the charge in your battery is below a certain level & is unable to provide enough voltage to fire a device & tank/RDA at your desired vaping wattage. All regulated devices with a chip in which you can choose your desired wattage have voltage protection, which means the device will not fire at a certain wattage if the battery does not have enough voltage or amps to output. This is for your protection; common warnings are “check battery” or “uneven battery levels”. Battery voltage drop-off normally occurs when your battery/batteries are under 40% fully charged
Storage Mistakes: Never store your batteries in direct heat, batteries should be stored in an area between 40 degrees to 80 degrees Fahrenheit to maximize battery life and safety.
Use Cases: Always use a plastic or non-conductive battery case or sleeve. If you store loose batteries in your bag or pocket it may conduct with your loose change or the metal from your keys.
Correct Battery: Always use the correct battery for the job, be that for regulated or mechanical devices. Know your OHM's law and refer to recommendations from Mooch's testing.
Battery Orientation: Always follow the manufacturers instructions on regulated and mechanical devices regarding which way to orient your batteries. If a Mechanical device has no specific instructions then always put your battery positive up to help prevent venting in a dead short situation.
Every 18650, 20700, 21700 etc battery in the market today, is a Lithium-Ion battery cell. Here are some important safety tips for rechargeable batteries:
Battery Damage: Never use a damaged battery, such as a dented battery or a battery that has its wrapping damaged. The plastic wrap on the battery and the white insulator on the positive side protects the battery from venting.
Charging: It is highly recommended to not use the micro USB charging port to recharge your device, especially if it is a device that uses 2 or more batteries. A micro USB cable and a wall-charging block are not designed to handle the proper voltage & current. The micro-USB port is mostly designed for firmware updates.
Charger Type: It is preferable to use an external Lithium Ion battery charger. These specific chargers provide a microchip that charges your batteries at the proper voltage, voltage control & overcharge protection.
Discharge: Never fully discharge a battery, but if you do so, you MUST recharge the battery within 24 hours in a proper external battery charger.
Voltage Drop-Off: Fully discharging a battery leads into the topic of battery voltage drop-off, which occurs when the charge in your battery is below a certain level & is unable to provide enough voltage to fire a device & tank/RDA at your desired vaping wattage. All regulated devices with a chip in which you can choose your desired wattage have voltage protection, which means the device will not fire at a certain wattage if the battery does not have enough voltage or amps to output. This is for your protection; common warnings are “check battery” or “uneven battery levels”. Battery voltage drop-off normally occurs when your battery/batteries are under 40% fully charged
Storage Mistakes: Never store your batteries in direct heat, batteries should be stored in an area between 40 degrees to 80 degrees Fahrenheit to maximize battery life and safety.
Use Cases: Always use a plastic or non-conductive battery case or sleeve. If you store loose batteries in your bag or pocket it may conduct with your loose change or the metal from your keys.
Correct Battery: Always use the correct battery for the job, be that for regulated or mechanical devices. Know your OHM's law and refer to recommendations from Mooch's testing.
Battery Orientation: Always follow the manufacturers instructions on regulated and mechanical devices regarding which way to orient your batteries. If a Mechanical device has no specific instructions then always put your battery positive up to help prevent venting in a dead short situation.